网站公告:

新闻中心

济南精拓流体设备有限公司

电话:0531-69951198

邮箱:jingtuolt@163.com

传真:0531-69951198

地址:济南市历城区西周南路9号

网址:http://www.sdjingtuo.com

常见问题

当前位置:首页 - 新闻中心 - 常见问题 - 连续运行气液增压泵有无影

连续运行气液增压泵有无影响要看实际而定

发布时间:2023-01-06 14:04:57   发布人:http://www.sdjingtuo.com
随着现代工业使用的增压泵的厂家越来越多,那么,对于使用气液增压泵来说,连续运行气液增压泵可以吗?对设备本身有什么影响?在讲解这些问题之前,需要就情况而分析,总结下来有以下两种情况:
With more and more manufacturers of pneumatic booster pumps used in modern industry, is it possible to continuously operate the pneumatic booster pumps for the use of gas-liquid booster pumps? What is the impact on the equipment itself? Before explaining these problems, we need to analyze the situation and summarize the following two situations:
1.气液增压泵24小时不间断工作增压,长时间负荷运行。
1. The gas-liquid booster pump works 24 hours a day to pressurize continuously and operates under load for a long time.
2.气液增压泵24小时工作,但每隔2-3小时会停止增压运行10分钟左右。
2. The gas-liquid booster pump works 24 hours a day, but stops pressurizing for about 10 minutes every 2-3 hours.
针对以上两种情况,我们来分析一下:
For the above two situations, let's analyze:
一种情况,24小时长时间负荷运行工作,会造成气液增压泵以下几方面影响。密封圈24小时连续摩擦会导致发热变软,老化变形。密封圈和缸筒之间不间断摩擦时间长了,会引起密封圈过度磨损影响其使用寿命。造成内部零部件无法进行定期保养,影响其使用寿命。那么如果再次工况下,应该怎么解决气液增压泵这种长时间负荷使用的问题呢?
In one case, the long load operation for 24 hours will cause the following impacts on the gas-liquid booster pump. The seal ring will be heated, softened, aged and deformed if it is continuously rubbed for 24 hours. The long time of uninterrupted friction between the seal ring and the cylinder barrel will cause excessive wear of the seal ring and affect its service life. As a result, the internal parts cannot be maintained regularly, affecting their service life. Then, how to solve the problem of gas-liquid booster pump that has been used for a long time under the working condition again?
气液增压泵
1:多备用一套气液增压泵,备用气液增压泵和原来气液增压泵可以进行交替使用(如2-4小时切换使用一次)
1: One set of gas-liquid booster pump shall be standby, and the standby gas-liquid booster pump and the original gas-liquid booster pump can be used alternately (for example, once every 2-4 hours)
2:在原有的气液增压泵上再增加一台气液增压泵,也就是我们常说的双泵系统,让气液增压泵不在满负荷工作,做到间歇性运行。其原理是利用气液增压泵的增压流量大于设备消耗气体流量,这时在流量多出来时气液增压泵因其自身原理会停止工作,达到休息作用。
2: Add another gas-liquid booster pump to the original gas-liquid booster pump, which is also known as the double pump system, so that the gas-liquid booster pump does not work at full load and operates intermittently. Its principle is that the pressurization flow of the gas-liquid booster pump is greater than the gas flow consumed by the equipment. At this time, the gas-liquid booster pump will stop working due to its own principle when the flow is excessive, so as to achieve the function of rest.
另一种情况下24小时间断性使用,需要明白气液增压泵是否满负荷运作和中间间歇时间,如满负荷工作2-4小时间歇10分钟,这种就要另备一套气液增压泵或者添加气液增压泵。间歇20分钟以上就没有问题。
On the other hand, if the gas liquid booster pump is used for 24 hours without interruption, it is necessary to know whether it operates at full load and intermittently. If it works at full load for 2-4 hours and breaks for 10 minutes, another set of gas liquid booster pump shall be prepared or added. There is no problem if the interval is more than 20 minutes.
有客户反映,使用气液增压泵工作个几分钟因为压缩空气饱和会停止工作1-2分钟,如果是这种保压情况下,气液增压泵可以24小时不间断使用。
A customer said that the gas-liquid booster pump will stop working for 1-2 minutes after it works for a few minutes because the compressed air is saturated. If the pressure is maintained, the gas-liquid booster pump can be used 24 hours without interruption.
连续运行气液增压泵有没有影响,要看现场实际情况而定,有的可以24小时连续使用,有的就不行。像这种情况要根据现场工况和锐拓机械说明书,为的就是防止气液增压泵使用不当造成的寿命减短。更多相关内容就来我们网站http://www.sdjingtuo.com进行咨询!
Whether the continuous operation of the gas-liquid booster pump has any impact depends on the actual situation on site. Some can be used for 24 hours continuously, while others cannot. In this case, the service life of the gas-liquid booster pump should be shortened due to improper use according to the on-site working conditions and the instructions of Rio Tinto machinery. More relevant content will come to our website http://www.sdjingtuo.com Consult! 
新闻推荐:
进行气液增压泵保护和运用的进程事项 2023-02-03
简述安装高压气体增压泵的六大步骤 2023-02-02
当我们给气液增压泵排障时要怎么做 2023-01-10
连续运行气液增压泵有无影响要看实际而定 2023-01-06
气体增压泵使用方法也比较简单 2022-12-31
降低增压泵系统的温度的措施 2022-12-31
初次使用气液增压泵的用户要避免七个使... 2022-12-26
选购气体增压泵时建议从7个方面入手 2022-12-21
气液增压泵的安装需多加了解一些要点 2022-12-14
关于气体增压泵的挑选和运用 2022-12-05

13188935873

qq