热线电话
0531-69951198
网站首页
关于精拓
产品展厅
新闻中心
原理选型
客户案例
在线留言
联系我们
网站公告:

新闻中心

济南精拓流体设备有限公司

电话:0531-69951198

邮箱:jingtuolt@163.com

传真:0531-69951198

地址:济南市历城区祝甸北路2号院

网址:http://www.sdjingtuo.com

业内资讯

当前位置:首页 - 新闻中心 - 业内资讯有关气体增压泵基础知识的

有关气体增压泵基础知识的解答

发布时间:2022-09-24 16:52:31   发布人:http://www.sdjingtuo.com
气体增压泵是一级增压机,依靠工厂气源作为驱动源,驱动泵内的活塞,利用泵体上的换向阀驱动泵体往复运动。加压,或氮气,氧气,氦气,氢气等清洁气体的压力增加。下面小编就来讲讲有关气体增压泵基础知识吧。
The gas booster pump is a primary booster, which relies on the factory air source as the driving source to drive the piston in the pump, and uses the reversing valve on the pump body to drive the pump body to and fro. Pressurization, or the pressure of nitrogen, oxygen, helium, hydrogen and other clean gases increases. Now let's talk about the basic knowledge of gas booster pump.
气体增压泵原理?
Principle of gas booster pump?
原理是大活,塞推动小活,塞往复运动实现增压,随着压力的出口端压力的上升,大活,塞和小活,塞的两端的力趋于平衡,故增压泵运动频率下降、流量变小,当出口端的压力是增压泵的增压比时,两端力值平衡,增压泵这时停止工作,流量为0,一旦一端气压下降,增压泵会自动工作,补齐压力,具有自动保压、补压功能。
The principle is big live, the plug pushes small live, and the plug reciprocates to realize pressurization. With the increase of the pressure at the outlet end of the pressure, the force at both ends of the plug tends to balance, so the motion frequency of the booster pump decreases and the flow decreases. When the pressure at the outlet end is the pressurization ratio of the booster pump, the force values at both ends are balanced, and the booster pump stops working at this time, the flow is 0. Once the pressure at one end decreases, the booster pump will automatically work to supplement the pressure, It has the function of automatic pressure maintaining and supplementing.
耗气量的要求,一般要求流量1m3/min左右,耗气量不是一个固定值,当泵的负载越小时,泵的频率越快,负载越大时,泵的频率越慢,当达到泵的大输出压力时,泵停止工作,不在耗气。不建议选用220V电源的空气压缩机,220V的空压机排气量一般都较小,增压泵不能发挥出正常效能。
Requirements for air consumption: generally, the flow is about 1m3/min, and the air consumption is not a fixed value. When the load of the pump is smaller, the frequency of the pump is faster. When the load is larger, the frequency of the pump is slower. When the pump reaches the large output pressure, the pump stops working and does not consume air. It is not recommended to select air compressor with 220V power supply. The air displacement of 220V air compressor is generally small, and the booster pump cannot play a normal role.
气体增压泵
气体增压泵的使用寿命?
Service life of gas booster pump?
气体增压泵的寿命与泵体内密封环的寿命有关。通常,气体增压泵在当前使用环境中是清洁的,并且由气源加压,并且驱动气体源没有杂质。严格按照气泵制造商的要求使用时,使用寿命为3 - 5年。
The life of the gas booster pump is related to the life of the seal ring in the pump body. Generally, the gas booster pump is clean in the current use environment, pressurized by the gas source, and the drive gas source is free of impurities. The service life is 3 - 5 years when it is used strictly according to the requirements of the air pump manufacturer.
气体增压泵的是多少?
What is the price of gas booster pump?
气体增压泵的视压力而定,不同。一般来说,压力越高,越高。气体增压泵是否需要配备气瓶?气体增压泵的气瓶由客户现场的要求决定。如果客户只需要达到压力,则没有其他特殊要求,原则上需要配置气瓶。如果客户需要稳定压力输出,则须配置气瓶。
The price of the gas booster pump depends on the pressure, and the price is different. Generally speaking, the higher the pressure, the higher the price. Does the gas booster pump need to be equipped with gas cylinders? The gas cylinder of the gas booster pump is determined by the customer's site requirements. If the customer only needs to reach the pressure, there are no other special requirements. In principle, gas cylinders need to be configured. If the customer needs a stable pressure output, a gas cylinder must be equipped.
在日常使用中出现问题后,气体增压泵是否易于维修?
Is the gas booster pump easy to repair after problems occur in daily use?
维修费用是否高昂,气体增压泵的维护一般与密封有关。如果出现问题,您可以在时间向制造商确认。根据他们的知识,选择密封圈进行更换。
Whether the maintenance cost is high, the maintenance of the gas booster pump is generally related to the seal. If there is a problem, you can confirm with the manufacturer at the time. According to their knowledge, select the seal ring for replacement.
有关气体增压泵基础知识的解答就到这里吧,更多关于增压泵的事项或者有购买的需求,就来我们网站http://www.sdjingtuo.com进行咨询了解吧!
So far is the answer to the basic knowledge of the gas booster pump. For more information about the booster pump or purchase needs, please come to our website http://www.sdjingtuo.com Consult and understand!
新闻: