热线电话
0531-69951198
网站首页
关于精拓
产品展厅
新闻中心
原理选型
客户案例
在线留言
联系我们
网站公告:

新闻中心

济南精拓流体设备有限公司

电话:0531-69951198

邮箱:jingtuolt@163.com

传真:0531-69951198

地址:济南市历城区祝甸北路2号院

网址:http://www.sdjingtuo.com

企业动态

当前位置:首页 - 新闻中心 - 企业动态气体增压泵用水频次太大导

气体增压泵用水频次太大导致一直响的处理

发布时间:2023-01-09 16:18:49   发布人:http://www.sdjingtuo.com
气体增压泵用水频次太大导致一直响的现象出现,而如果增压泵是压差控制的,当频繁有用水时,也会造成一启一停的现象发生。其原因也是和出水管漏水是一样的,而且这种情况可能一起一停会更频繁,特别是没有气压罐稳压的尤为严重。
The frequent use of water by the gas booster pump leads to the phenomenon of constant noise. If the booster pump is controlled by differential pressure, the phenomenon of one start and one stop will also occur when there is frequent use of water. The reason is the same as the water leakage of the outlet pipe, and this situation may be more frequent when the pipes are stopped together, especially when there is no pressure tank to stabilize the pressure.
1、如果泵是用来吸水,请确认泵和吸水面的高度差是否过高(一般不建议超过3米)。因为吸水高度过高可能导致发生汽蚀现象,这时候泵腔里面也是可能会有异响的。
1. If the pump is used to absorb water, please confirm whether the height difference between the pump and the suction surface is too high (generally it is not recommended to exceed 3m). Because the suction height is too high, cavitation may occur. At this time, there may be abnormal noise in the pump chamber.
2、请确认在正式运行前对泵进行了排气,如果未排气,里面有空气也会有响声的。
2. Please confirm that the pump is vented before the official operation. If it is not vented, there will be a noise if there is air in it.
3、请确认吸水管是不是偶尔露出到水面外导致吸水时吸入空气而产生异响是否吸入了杂质
3. Please confirm whether the suction pipe is occasionally exposed out of the water surface, which causes abnormal sound when sucking in air, and whether impurities are inhaled
气体增压泵
4、如果以上可能都排除了,请拆开电机风罩,用手摇动电机风罩,慢慢摇动,注意感觉是不是到专了有个地方有明显的摩擦现象。如果是这样,那就是制造精度问题。还有一个问题,可能就是风罩和风扇叶子这里摩擦到了,请注意排除。
4. If all the above may be ruled out, please remove the motor hood, shake the motor hood manually and slowly, and pay attention to whether there is obvious friction phenomenon at a special place. If so, it is a question of manufacturing accuracy. Another problem may be the friction between the fan cover and the fan leaves. Please remove it.
如果要杜绝这种情况,建议将压差式控制器改为器控制,或者直接更换全新的增压泵可以解决用水时一响一停的现象。更多相关内容就来我们网站http://www.sdjingtuo.com进行留言咨询吧!
If this situation is to be eliminated, it is recommended to change the differential pressure controller to the controller control, or directly replace a new booster pump to solve the problem of "one sound and one stop" when using water. More relevant content will come to our website http://www.sdjingtuo.com Leave a message for consultation!
新闻: